Dear Label_Name,

Greetings! I hope you are well.

I am writing on behalf of an international publishing house, Science and Education Publishing, USA (http://www.sciepub.com).

Science and Education Publishing (SciEP) is a multidisciplinary open access publisher of Journals covering the fields of Science, Technology and Medicine. All SciEP publications are subject to high-quality peer review, editorial and production processes and are freely available online.

Welcome to the April, 2013 edition of SciEP newsletter, providing monthly summaries of articles on science & education related topics of interest to scientist and professionals. The mission of our journals is to provide an open access forum for publishing new findings on issues pertinent to scientific and academic field. We also invite you to submit original research papers, review articles, short reports, or case studies are considered for publication in our Multidisciplinary Journals.

American Journal of Public Health Research
DOI: 10.12691/ajphr-1-1-3

The Implementation of a Tele-Homecare System with Service Oriented Architecture and HL7 Message Transmission Standard
Ching-Sung Wang

American Journal of Medical and Biological Research
DOI: 10.12691/ajmbr-1-1-2

The Influence of Ethanol on Pyruvate Kinases Activity in Vivo, in Vitro, in Silico
Lelevich Sergey Vladimirovich, Khrustalev Vladislav Victorovich, Barkovsky Eugene Victorovich, Shedogubova Tatyana Aleksandrovna

American Journal of Medical Sciences and Medicine
DOI: 10.12691/ajmsm-1-1-1

Clinical and Histological Features in Wegener Granulomatosis
Li Cavoli Gioacchino, Passantino Rita, Bono Luisa, Tortorici Calogera, Ferrantelli Angelo, Giammarresi Carlo, Rotolo Ugo

American Journal of Infectious Diseases and Microbiology
DOI: 10.12691/ajidm-1-1-2

The Curse of Lymphatic Filariasis: Would the Continual Use of Diethylcarbamazine Eliminate this Scourge in Papua New Guinea?
Anne Lanham, Lillian Mwanri

We have released issues of some journals on February 2013.
American Journal of Public Health Research
American Journal of Medical Sciences and Medicine
American Journal of Medical and Biological Research
American Journal of Pharmacological Sciences
American Journal of Clinical Medicine Research
American Journal of Nursing Research
American Journal of Cancer Prevention
American Journal of Medicine Studies
American Journal of Infectious Diseases and Microbiology
American Journal of Cardiovascular Disease Research
American Journal of Biomedical Research
American Journal of Mechanical Engineering
American Journal of Microbiological Research
Journal of Preventive Medicine
American Journal of Food and Nutrition
American Journal of Hypertension Research
American Journal of Sports Science and Medicine
Journal of Cancer Research and Treatment
American Journal of Zoological Research
Journal of Biomedical Engineering and Technology
American Journal of Microbiological Research
Biomedical Science and Engineering

We are pleased to announce that submissions are now being accepted for peer review for all the journals across all our subject areas in SciEP.

Please submit your manuscript via our online submission system:
http://www.sciepub.com/author/signin

To unsubscribe from our mailing list, please click on the following link: unsubscribe

I am looking forward to hearing from you.

Kind regards,

David Rain
Email:join@sciepub.com
Science and Education Publishing (http://www.sciepub.com)

Cellulase Producing Bacteria Isolation, Screening and Media Optimization from Local Soil Sample

Md. Arju Hossain, Md. Akash Ahammed, Saiful Islam Sobuj, Siratul Kubra Shifat, Pratul Dipta Somadder*

Biotechnology and Genetic Engineering, Mawlana Bhashani Science and Technology University, Tangail, Bangladesh

Abstract: Cellulase enzyme earns consecutively increasing demand in industries of Bangladesh. This experiment has been planned to develop the enzyme industry in our country rather than import enzymes from other countries and conclude with isolating and screening cellulose-degrading bacteria from local land samples and ensuring maximum enzyme production through media optimization. After collecting soil samples from various Tangail areas, a typical dilution of series was performed on a Carboxymethylcellulose plate (CMC) to produce cellulase-producing microorganisms. Based on the hydrolysis zone of the ratio, four isolates were chosen and labeled CBM21, CSG8, CSR35, and CHT8 for further morphological and biochemical analysis. Then subjected to cellulase production in 250 ml of Erlenmeyer flask using CMC broth for 48 hours of fermentation at 37°C at an agitation rate of 140rpm, and cellulase enzyme assay methods evaluated crude enzymes. Eventually, those confirmed isolates were optimized using different parameters by submerged fermentation process for enhanced cellulase production. Among four isolates, CSG8 and CBM21 exhibited the maximum clearance zone with the hydrolytic values 6.96 and 8.46. These isolates were identified as Pseudomonas spp. (CSG8). According to the screening process, CBM21 (0.156U/ml), CSG08 (0.106U/ml), and E. coli (negative control) have been used for optimization with their initial enzyme productivity. After optimization, an amazing enhancement was noticed for CBM21 (1.35 U/ml) and CSG8 (1.23 U/ml) compared to E.coli (0.44 U/ml). The enzyme was characterized in isolates with an effective temperature of 40 and 35°C for CBM21 and CSG8, respectively, and pH 7, glucose 5% with the incubation time 24h was optimal. Aftermath, this type of optimization can be a significant initiative in the enzyme industries of Bangladesh.

Keywords: ellulase, isolation, screening, carboxymethylcellulose, optimization, hydrolysis

Received May 15, 2021; Revised June 19, 2021; Accepted June 27, 2021

Citation: Md. Arju Hossain, Md. Akash Ahammed, Saiful Islam Sobuj, Siratul Kubra Shifat, Pratul Dipta Somadder, Cellulase Producing Bacteria Isolation, Screening and Media Optimization from Local Soil Sample. American Journal of Microbiological Research, 9 (3). 62-74. January 2021. doi:10.12691/ajmr-9-3-1

1. Introduction

In biotechnological processes, enzymes are at the core. Cellulase is one of the most usable enzymes that act on cellulosic material. Also, the most abundant form of biomass on Earth is cellulose, consisting of a linear polysaccharide of glucose residues with -1, 4-glycosidic linkages [1]. Generally, cellulose is a significant plant component that accounts for 50 percent of the plant biomass's dry weight, and agricultural wastes, for example, make up about half of the dry weight of secondary biomass sources [2]. As decades of research have shown, cellulase enzyme has long been involved in producing fermentable sugars from lignocellulose biomass. Cellulases are usually made up of three groups of enzymes that work together: endoglucanases hydrolyzed the polymeric chain of cellulose, exoglucanases that aid in the release of cellobiose from the cellulose polymer, and 𝛽-glucosidases, which assist in the conversion of cellobiose to glucose [3]. Cellulase is generally secreted by various microorganisms, including fungi, bacteria, and Actinomycetes, which can dissolve cellulose [4]. Overall, many scientists noticed fungi mainly because they produce cellulases that are plentiful and easy to obtain. In recent years, specific fungal sources, including Trichoderma, Aspergillus, Penicillium, etc., have been widely used for industrial purposes.

In comparison to fungi, researchers have taken into consideration various bacteria which produce cellulases because of the exponential rise, production of a multi-enzymes complex with their susceptibility to severe conditions [5,6,7]. Some genera of bacteria, including Pseudomonas sp., Cellulomonas, and Cellvibrio [8], Micrococcus, and Bacillus [9], exhibit cellulolytic properties. Forest, rural areas, and agro-industrial waste have a considerable quantity of unused or underused cellulose that causes environmental pollution. By using enzymes including cellulase, amylase, fatty lipase, protease, etc., beneficial products like sugars, biofuels, animal feed, and human nutrition are now being produced [10].

Cellulase can help to protect seeds and plants against plant pathogens, as a biocontrol [11]. Many cellulolytic microorganisms have been known for improved germination, the rapid growth of plants, and a boost in crop yields [12]. For instance, this enzyme that degrades cellulose may be used to produce washing powders, extract fruit and vegetable juices, and refining starch [13]. In the textile sector, cellulases are used to make cotton and denim finishes; for the maintenance of color in laundry detergents; to increase drainage and fiber alteration in the pulp and paper industries, and very recently applied in the biomedical research industry [14]. Cellulases convert cellulosic material to glucose and other products, which can be used as a microbial substrate material for single-cell protein and bioethanol production [15].

Some potential experiments were performed to explore the aerobic bacterial development in carboxymethyl cellulase (CMCase) medium. In the late logarithm step, Acinetobacter anitratus shows the highest activity for CMCases media [16]. The cellulase productivity appears to depend on a complex relationship with certain parameters such as pH, temperature, aeration, inoculum volume, and incubation time. The researchers conclude that Paenibacillus sp's strain shows high potential for the optimal development of cellulase in a 1.0% CMC containing medium [9]. Besides, some cellulose-decomposing bacteria showing CMCase activity within the 0.162–0.400 U/mL range were isolated from the Gupta et al. experiment [17].

Deka et al.' used a surface reaction technique for optimizing cellulase development by aerobic bacteria, observing that the maximum CMCase activity of Bacillus subtilis AS3 is 0.43 U/ml [18]. The CMCase activity of the ACCA2 strain of Enhydrobacter sp. was continuously optimized in order to optimize medium components such as carboxymethyl cellulose, peptone, sodium chloride, (NH4)2SO4, K2HPO4, and MgSO4, which resulted in a 2.39 fold increase in CMCase activity. [19]. In addition, setting up an optimized condition, Da Vinha et al. calculated that the maximum activity of CMCase is 2.0 U/ml. While using the Streptomyces viridobrunneus SCPE-09 and Pseudomonas sp. Hp207 strain, Sheng et al. reported 1.432 U/ml [20,21].

Global Cellulase's Market Report for 2018 reveals that Asia Pacific is the largest purchaser of cellulases and added that cellulase application would hit USD 2300 million by 2025, which will increase by 5.5% over the 2018-2025 period, at an annual CAGR (compound annual growth rate) [4]. The production of cellulase enzymes in the future most exciting advanced field of research by biotechnology with several factors, including cost, genetic engineering, a particular activity, and purification steps that are feasible in research interests.

The degradation of cellulosic materials has been identified in numerous investigations. Still, few studies have examined which microorganisms, especially bacteria, could be used as the best source of cellulase enzyme production for industrial purposes. For this reason, there is a growing demand for the isolation of bacterial aerobic strains, which reasonably produce higher cellulase activity.

Our study has conducted by isolating aerobic bacteria from a local soil sample that could hydrolyze cellulosic material. Besides, further identified those bacterial isolates by the growth of selective media. Current work was also done to optimize media parameters for improving the output of cellulose employing identified bacterial isolates. In conclusion, the bacterial isolates CBM21 produces 1.35 U/mL CMCase activity after modifying the cultural condition compared to others isolates.

2. Materials and Methods

2.1. Study Place and Design

This investigation was carried out in the Biotechnology and Genetical Engineering laboratory, Mawlana Bhashani University of Science and Technology, Santosh, Tangail, Bangladesh. The flow diagram of the study plan was shown in supplementary Figure 1.

Figure 1. Ratio of hydrolysis zone diameter and colony diameter (z/n) (mm)

2.2. Isolation of Bacteria

The soil samples used in this experiment were collected from the various regions such as green wastes, tannery wastes, garden soil, tannery industry wastes, rice straw wastes, forest soil and stored at 4°C until used. Traditional serial dilution technique has been used to isolate cellulolytic bacteria through agar plate about 10⁻¹ to 10-7 dilution factor. From the test tubes labeled 10-6 and 10⁻⁷, 0.1 ml is applied on the media of carboxymethyl cellulose (CMC) containing: 1.0% carboxymethyl cellulose (CMC), 1.0% peptone, 0.2% (NH₄)₂SO4, 0.2% K₂HPO₄, 0.03% MgSO4.7H2O and 0.2% gelatin and 1% agar [22]. The CMC agar plates were subsequently incubated for 24 hours at 37°C. Different discrete colonies were found on an agar plate and were selected further.

2.3. Primary Screening of Cellulose Degrading Bacteria

CMC agar plates had been soaked with iodine solution for approximately 5 minutes and then allowed to stand at room temperature. Several colonies were shown a clear circular zone on the agar plate. The respective broth culture which were shown clear zone were streak on CMC agar media containing 1.0 % carboxymethylcellulose, 0.1% KH₂PO₄, 0.005% NaCl, 0.04 % MgSO₄.7H₂O, 0.1 % K₂HPO₄, 0.000125% FeSO₄, 1.8 % agar, pH 7.0 and incubate at 37°C for 72 hours [23]. The plates were further flooded with iodine and allowed to stand at room temperature for around five minutes. The CMC hydrolysis clear zone and colony diameter ratio were measured and reported.

For cellulase development in a submerged environment, the bacterial colonies with the largest ratio were selected.

2.4. Identification of Bacteria

2.4.1. Morphological and Biochemical Characteristics

Bacterial isolates were pre-sumptuously characterized by morphology, as well as some biochemical analysis. The parameters investigated included colonial morphology (evaluated for size, pigmentation, form, margin, elevation, and texture), gram reactions, citrate utilization test, MIU (Motility- Indole- Urease) test, catalase production, Kligler’s Iron Agar (KIA) test.

2.4.2. Identification of Bacterial isolates on Selective Media

Pseudomonas sp. is isolated and identified using Cetrimide Agar, a selective and differential medium. Cetrimide media composition pancreatic digest of gelatin 2.0%, K₂SO4 1.0%, MgCl2 0.1%, C₁₉H₄₂BrN 0.03%, glycerin 1%, agar 1.36%. The selective agent of cetrimide inhibits most bacteria as it functions as a detergent. For several years, therefore, 0.03 % cetrimide agar has been used and found to be efficient in isolation of Pseudomonas sp. [24].

2.5. Secondary Screening for Cellulase Enzyme Production

Potential isolates for enzyme efficiency have been examined. The maximum cellulase production isolates were considered for the following study.

2.5.1. Inoculum Development

The maximum hydrolysis zone of these isolates is grown in 20 ml inoculum production medium [composition: Carboxymethylcellulose (CMC) 0.5%; Tryptone 0.20%; KH₂PO₄ 0.4%; MgSO₄.7H₂O 0.02%, Na₂HPO4 0.04%, CaCl₂.2H₂O 0.0001%; FeSO₄.7H₂O 0.0004% and pH adjusted to 7.0] separately and cultivated 24 hours at 37°C. It was used as an inoculum medium subsequently the source of production medium [22].

2.5.2. Crude Enzyme Production by Submerged Fermentation Process

CMC broth containing Carboxymethylcellulose (CMC) 1.0%; Tryptone 0.20%; KH₂PO₄ 0.4%; Na₂HPO₄ 0.04%; MgSO₄.7H₂O 0.02%; CaCl₂.2H₂O 0.0001%; FeSO₄.7H₂O 0.0004% was prepared and allocate 50ml in 250 ml Erlenmeyer flasks for each of the selected isolated strains. The media were inoculated with 2.5ml (5%) of the selected bacterial isolate from the inoculum media and incubated at 37°C for 48hrs at 150 rpm. After fermentation, the fermented broth was centrifugated to remove undesired materials at 12000 rpm for 10 minutes at 4°C. At the end of centrifugation, the clear supernatant was collected to serve as a crude enzyme source and used to determine enzymatic activity [25].

2.5.3. Cellulase Enzyme Assay

The DNSA method was used to determine how much reducing sugar was liberated during the hydrolysis. Under the following standard assay conditions, the enzyme unit (EU) was calculated as the amount of cellulase required to release 1 mole of reducing sugar per ml per minute [25].

The cellulase activities of each of the bacterial strains were assayed in triplicate. The reaction mixes included a buffer of 1ml 0.05M citrate (pH 4.8), 1 ml substrate solution (1% CMC dissolved in citrate buffer), and 1 ml crude enzyme solution. Instead of the enzyme, the blanks had 1 ml of distilled water for 30 minutes at 50°C. Following incubation, 1.5 ml DNS reagent was applied to the test tubes to end the reaction, waited 10 minutes, and then boiling in water baths at 100°C for 10 minutes. The absorbance was measured at 575nm. Glucose release was measured with the glucose calibration curve [26], and enzymatic activity was determined by the following equation [27].

2.6. Optimization Process for Maximum Cellulase Production

Cellulase activity of the culture supernatant of bacteria was grown at different temperatures, pH, carbon sources, and incubation periods.

2.6.1. PH

The optimal substrate and carbon source concentration are taken, and the broth pH is balanced at 6.0, 7.0, 8.0, 9.0, and 10.0 in the various conical flask using 1 N HCl and 1 N NaOH as well as autoclaved. Cultures are inoculated and cultivated at specific temperatures. The cell mass was separated by centrifugation after 24 hours of fermentation at 37°C with 150 rpm shaking, and cell-free culture filtrate was obtained as an enzyme source [28].

2.6.2. Incubation Temperature

The initial pH 7 of the production medium was adjusted and then inoculated with selected bacterial isolates that had been grown overnight. At 150 rpm, the broth was incubated at various temperatures ranging from 30, 35, 40, 45, and 50°C. The filtrate of cell-free culture is collected after 24 hours of incubation and used as a source of crude enzymes.

2.6.3. Concentration of Glucose

Different glucose concentrations were used to substitute the original concentration of 1 % sugar in growth media with 2 to 5 % sugar, and all parameters were set to an optimal level.

2.6.4. Carbon Sources

Several carbon substitutes, including fructose, lactose, and sugar, have been used as an initial source of carbon in growth media to compensate for glucose. The impact of these sources on the production medium was analyzed at 5% concentration when pH, temperature, incubation time was fixed at 7.0, 37°C, and 24 hours respectively, in a shaking incubator.

2.6.5. Incubation Period

The incubation period has optimized for the cellulase production and the pH of the production media broth was adjusted to 7.0. In a shaking incubator, 1 ml inoculum was then added to 50 ml of fermentation broth at 37°C with 150 rpm. The fermentation product was withdrawn at different time intervals, e.g., 16, 24, 36, 48, and 72 hours and then centrifuged at 12000 rpm for 10 minutes at 4°C. After centrifugation, for cellulase testing, the supernatant was used to approximate a standard glucose curve.

3. Result and Discussion

3.1. Isolation and Primary Screening for Cellulase Producing Bacteria

In this analysis, ten samples were collected from 5 different locations, yielding 40 isolates from each sample using the dilution 10⁻⁶ and 10⁻⁷ plates. From these, 160 out of 200 isolates were removed due to non-cellulolytic. The 40 isolates were then screened for cellulase activity on CMC agar using iodine staining, whereas congo red staining did not yield an effective result. According to Gohel et al. studies, the best results are obtained using grams of iodine, accompanied by congo red staining [29]. Gomashe et al. and Gupta et al. backed up our findings in the same enzymatic sense [17,30].

Figure 2. Hydrolysis zone after flooded with iodine

As a consequence, native microbes can be a source of cellulase that can be investigated for use in a variety of applications. The CMCase activity is shown in Figure 1; of both the four isolates, the highest ratio of the apparent zone diameter to the colony diameter on the CMC agar plate was determined compared to other isolates (Figure 2). Out of 43 isolates, four isolates were efficient cellulase producers and analyzed for secondary screening.

3.2. Colony Morphological and Biochemical Characterization

CBM21 isolates produced diffusible whitish, and CSG08 isolates green pigment with irregular and smooth translucent raised colonies on nutrient agar plate based on morphological and biochemical characteristics. On gram staining, all isolates showed gram-negative without CBM21 (Table 1). Although, four isolates were showed citrate and catalase-positive after biochemical tests. Based on morphological, cultural, and biochemical research, the CBM21, CSG08, CHT08, and CSR35 isolates were presumptively identified as a Bacillus spp., Pseudomonas spp., Klebsiella spp. and Serratia spp., respectively. The results of the tests are given in the following Table 2 and Figure 3.

Table 1. Colony Characteristics and Gram Reaction

Figure 3. Results of biochemical test

Table 2. Results of Gram Biochemical Test

Figure 4. Blue-green colonies on a cetrimide agar plate

3.3. CSG-08 Culture on a Cetrimide Agar Plate

Colonies exhibiting blue-green pigmentation are considered presumptive positive, and it is regarded as Pseudomonas spp. (Figure 4). In the study of cellulolytic bacteria, Talia et al. [31] discovered that Pseudomonas spp. dominated in soil samples obtained from native Chaco soil.

3.4. Measurement of Cellulase Activity

The possible four bacterial isolates (CBM21, CSG08, CHT8, and CSR35) were identified after screening and detection to evaluate their enzyme activity in the submerged fermentation process. Crude enzyme samples were tested using the enzyme activity technique. The maximum cellulase activities of the isolate CBM21 were found 0.156 U/ml compared to other isolates, as shown in Table 3.

Table 3. Activity of enzyme from different isolates

Gupta et al. [17] found in their studies several cellulose-degrading bacteria with cellulase activity ranging from 0.162 to 0.400 U/ml. In contrast, another study by Ekperigin M.M., 2007 demonstrated that the A. Anitratus and Branhamella spp. Produced highest enzyme activity was 0.48 and 2.56 U/ml for CMC, respectively [32]. Both findings supported our results by comparing with their studies.

3.5. Optimizing the Production of Cellulase

For cellulase development from selected isolates, the different optimal parameters were calculated.

3.5.1. The Effect of pH on the Production of Enzymes

The media with different pH ranged from 6.0 to 10.0 allowed two isolates and E.coli to grow. In CBM21 and CSG8, maximum enzyme activity in pH 7.0 was observed, compared with E.coli. However, the enzyme activity has been reduced by increasing pH. This result was compared to a standard glucose curve, consistent with other researchers' findings that most bacteria are best suited to pH 6 to 8 [33,34]. Shown in Figure 5.

3.5.2. The Effect of Incubation Temperature on Enzyme Production

Regulation of the enzymes reported at various temperatures showed that all three bacteria produced maximum cellulase at 35 to 40°C. This Figure 6 result showed that for optimal CBM21 and E. coli, the optimum temperature was 40°C while CSG about 35°C. The temperature was determined by adjusting the physical properties of the cell membrane to affect extracellular enzyme secretion. Bakare et al. claimed that [35] the Pseudomonas fluorescence produced cellulase enzyme during 30 to 35°C with showing the best result at 35°C temperature. On the other hand, Bacillus subtilis 115 and Bacillus subtilis were optimally temperature at 40°C.; also, minimum cellulase yield was observed in fermentation at 45°C [36], while Bacillus subtilis and Bacillus circulans achieved optimum yield at 40°C [9].

3.5.3. Effect of Different Concentration of Glucose

Results obtained from Figure 7 showed that 5% glucose exhibited the highest cellulase activity compared to other glucose concentrations. CBM21 and CSG8 were produced the highest amount of enzyme (1.23 and 1.31 U/ml) than E.coli, where it produced 0.44U/ml.

3.5.4. Effect of Different Carbon Source on Enzyme Production

To substitute 1% sugar, which was the initial concentration in growth media, with 2 to 5 % carbon sources, different concentrations of carbon sources were used. The findings revealed that 5% of the carbon source, including glucose and lactose, brought the highest cellulase production for CBM21 and CSG8 compared to other concentrations of carbon sources at 24 h incubation. Figure 8 showed that fructose produced high cellulase only for E.coli spp. that serves as a control group at 24 h of incubation. In comparison to other studies, the best source of cellulase activity was found to be glucose [37]. Saraswati et al. [38] claimed that the best carbon source of Bacillus subtilis was lactose extracted from cow dung to produce optimal cellulase. But in another study by Teodoro and Martins [39] revealed that maltose had been used for Bacillus spp. as the best source of carbon.

3.5.5. Effect of Different Incubation Period on Enzyme Production

Figure 9 illustrated the correlation between the incubation period and enzyme activity. It was observed that the level of cellulase increased from 24 to 48 h and after that decreased more rapidly as the fermentation its endpoint. The work currently shows that the synthesis of enzymes is reduced when the incubation time reaches the optimal time. Haq et al. [40] also suggested that a decrease in incubation enzymatic activity could be due to nutrient depletion and in the fermentation medium, the formation of other by-products. At the same time, another study by Ariffin et al. [41], concluded that the inactivation of enzyme secretion is associated with bacterial stress caused by nutrient depletion in the medium. However, the highest activity of the enzymes was observed in our research at 24 hours of bacterial culture.

Figure 5. Effect of pH on cellulase activity

Figure 6. Effect of Incubation temperature on cellulase activity

Figure 7. Effect of glucose concentration on cellulase activity

Figure 8. Effect of carbon source on cellulase activity

Figure 9. Effect of incubation period on cellulase activity

4. Conclusions

A wide range of cellulolytic bacteria can be found in soil, including those that have yet to be isolated. This research was done to isolate potential cellulase-producing bacterial isolates from soil samples. Specific isolates were selected due to breaking down cellulose activity and cellulolytic characteristics. Among all these four isolates CBM21, CSG08, CSR35, and CHT08 were picked for possible cellulase activity determination as their ratio of colony diameter and clear zone diameter were higher than others. Based on colony morphology, selective culture, and biochemical analysis of these four isolates, CSG08 was presumptively identified as organisms from Pseudomonas species. It was also confirmed after observing bluish-green colonies on particular selective media. Partial purification of the cellulase enzyme has been performed, and the function of the enzyme is determined by the DNSA method. CBM21 and CSG08 were found to be highly active in our research as their enzyme activity was determined to be 0.156 U/ml and 0.106 U/ml compared to other isolates.

The production of cellulase for each isolate has been optimized to determine optimal parameters for stability and ensure better enzyme production and enzyme activity. After optimization, an amazing enhancement was noticed for CBM21 (1.35 U/ml) and CSG8 (1.23 U/ml) compared to E.coli = 0.44 U/ml. The enzyme was characterized by an optimum incubation temperature of 40 and 35°C for CBM21 and CSG8, respectively, and pH seven was found to be optimal after 24 h incubation period and 5 % glucose used as a single carbon source. These optimized requirements can be seen in various industrial sectors. Further large-scale culture studies are required by mutagenesis and protein engineering techniques to optimize other parameters, including inoculum concentration, inducer presence, and medium additives.

Acknowledgments

The authors are thankful to the Biotechnology and Genetic Engineering department of MBSTU for permitting to conduct the study. The authors are grateful to all the responder who gave their valuable time and information for making this study done.

References

Supplementary

Table S1. Different sample collection site for cellulase enzyme production

Figure S1. Flow diagram of the study design

Figure S2. Dilute sample culture on CMC agar plate and flooded with iodine solution

[1]   | Patagundi, B. I., Shivasharan, C. T. and Kaliwal, B. B., “Isolation and characterization of cellulase producing bacteria from soil,” International Journal of Current Microbiology and Applied Sciences, 3(5), 59-69, 2014.
[2]   | Kato, S., Haruta, S., Cui, Z.J., Ishii, M., Igarashi, Y., “Effective cellulose degradation by a mixed-culture system composed of a cellulolytic Clostridium and aerobic non-cellulolytic bacteria,” FEMS Microbiology Ecology, 51(1), 133-142, 2004.

[3]  
Brás, J. L. A., Cartmell, A., Carvalho, A. L. M., Verzé, G., Bayer, E. A., Vazana, Y., Correia, M. A. S., Prates, J.A. M., Ratnaparkhe, S., Boraston, A. B., Romão, M. J., Fontes, C. M. G. A., and Gilbert, H. J., “Structural insights into a unique cellulase fold and mechanism of cellulose hydrolysis,” Proceedings of the National Academy of Sciences of the United States of America, 108(13), 5237-5242, 2011.

[4]   | Jayasekara, Sandhya & Ratnayake, Renuka, “Microbial cellulases: an overview and applications,” Cellulose, 22, 2019.
[5]   | Gusakov, A. and Sinitsyn, A., “Cellulases from Penicillium species for producing fuels from biomass,” Biofuels, 3, 463-477, 2012.
[6]   | Maki, M., Leung, K. and Qin, W., “The prospects of cellulase-producing bacteria for the bioconversion of lignocellulosic biomass,” International Journal of Biological Sciences, 5, 500-516, 2009.
[7]   | Deswal, D., Khasa, Y. P. and Kuhad, R. C., “Optimization of cellulase production by a brown rot fungus Fomitopsis sp RCK2010 under solid state fermentation,” Bioresource technology, 102(10), 6065-6072, 2011.
[8]   | Nakamura, K. And Kitamura, K., “Isolation and identification of crystalline cellulose hydrolyzing bacterium and its enzymatic properties,” Journal of Fermentation Technology, 60(4), 343-348, 1982.
[9]   | Immanuel G, Dhanusha R, Prema P, Palavesam A., “Effect of different growth parameters on endoglucanase enzyme activity by bacteria isolated from coir retting effluents of estuarine environment,” International Journal of Environmental Science & Technology, 3(1), 25-34, Dec 2006.
[10]   | Tomme, P., Warren, R. A. J. and Gilkes, N. R., Cellulose Hydrolysis by Bacteria and Fungi, in Poole, Academic Press (Advances in Microbial Physiology), 37, 1-81, 1995.
[11]   | Zeilinger, S., Ebner, A., Marosits, T., Mach, R. and Kubicek, C., “The Hypocrea jecorina HAP 2/3/5 protein complex binds to the inverted CCAAT-box (ATTGG) within the cbh2 (cellobiohydrolase II-gene) activating element”, Molecular Genetics and Genomics, 266(1), 56-63, 2001.
[12]   | Teeri, T. T., Lehtovaara, P., Kauppinen, S., Salovuori, I. and Knowles, J., “Homologous domains in Trichoderma reesei cellulolytic enzymes: gene sequence and expression of cellobiohydrolase II,” Gene, 51(1), 43-52, 1987.
[13]   | Camassola, M. and Dillon, A. J. P., “Production of cellulases and hemicellulases by Penicillium echinulatum grown on pretreated sugar cane bagasse and wheat bran in solid-state fermentation,” Journal of Applied Microbiology, 103(6), 2196-2204, 2007.
[14]   | Kuhad, R. C., Gupta, R. and Singh, A., “Microbial cellulases and their industrial applications,” Enzyme Research, 2011, 2011.
[15]   | Béguin, P. and Aubert, J.-P., “The biological degradation of cellulose,” FEMS Microbiology Reviews, 13(1), 25-58, 1994.
[16]   | Ekperigin, M. M., “Preliminary studies of cellulase production by Acinetobacter anitratus and Branhamella sp,” African Journal of Biotechnology, 6(1), 2007.
[17]   | Gupta P., Samant K. and Sahu A., “Isolation of cellulose degrading bacteria and determination of their cellulolytic potential,” International Journal of Microbiology, 2012, 1-5, 2012.
[18]   | Deka, D., Bhargavi, P., Sharma, A., Goyal, D., Jawed, M. and Goyal, A., “Enhancement of cellulase activity from a new strain of Bacillus subtilis by medium optimization and analysis with various cellulosic substrates,” Enzyme Research, 2011, 2011.
[19]   | Waghmare, P. R., Patil, S.M., Jadhav, S.L., Jeon, B.H. and Govindwar, S.P., “Utilization of agricultural waste biomass by cellulolytic isolate Enterobacter sp. SUK-Bio,” Agriculture and Natural Resources, 52(5), 399-406, 2018.

[20]  
Da Vinha, F. N. M., Gravina-Oliveira, M.P., Franco, M.N., Macrae, A., da Silva Bon, E.P., Nascimento, R.P., and Coelho, R.R.R., “Cellulase production by Streptomyces viridobrunneus SCPE-09 using lignocellulosic biomass as inducer substrate,” Applied Biochemistry and Biotechnology, 164(3), 256-267, 2011.

[21]   | Sheng, P., Huang, S., Wang, Q., Wang, A. and Zhang, H., “Isolation, screening, and optimization of the fermentation conditions of highly cellulolytic bacteria from the hindgut of Holotrichia parallela larvae (Coleoptera: Scarabaeidae),” Applied Biochemistry and Biotechnology, 167(2), 270-284, 2012.
[22]   | Irfan, M., Safdar, A., Syed, Q. and Nadeem, M., “Isolation and screening of cellulolytic bacteria from soil and optimization of cellulase production and activity,” Turkish Journal of Biochemistry/Turk Biyokimya Dergisi, 37(3), 287-293, 2012.
[23]   | Khatiwada, P., Ahmed, J., Sohag, M.H., Islam, K. and Azad, A.K., “Isolation, screening and characterization of cellulase producing bacterial isolates from municipal solid wastes and rice straw wastes,” J Bioprocess Biotech, 6(280), p.2, 2016.
[24]   | Lowbury, E. J., & Collins, A. G. 1955. “The use of a new cetrimide product in a selective medium for Pseudomonas pyocyanea,” Journal of Clinical Pathology, 8(1), 47-48, 1955.
[25]   | Shaikh, N.M., Patel, A.A., Mehta, S.A. and Patel, N.D., “Isolation and Screening of Cellulolytic Bacteria Inhabiting Different Environment and Optimization of Cellulase Production” Universal Journal of Environmental Research & Technology, 3(1), 2013.
[26]   | Shoham, Y., Lamed, R. and Bayer, E.A., “The cellulosome concept as an efficient microbial strategy for the degradation of insoluble polysaccharides,” Trends in Microbiology, 7(7), 275-281, 1999.
[27]   | Islam, M.S., Aktar, M.B. and Rahman, M.M., “Determination of alpha-amylase activity of Streptomyces spp isolated from Bangladeshi soils,” 2014.
[28]   | Sethi, S., Datta, A., Gupta, B.L. and Gupta, S., “Optimization of cellulase production from bacteria isolated from soil,” International Scholarly Research Notices, 2013.

[29]  
Gohel H.R., Contractor C.N., Ghosh S.K. and Braganza V.J., “A comparative study of various staining techniques for determination of extra cellular cellulase activity on Carboxy Methyl Cellulose (CMC) agar plates,” International Journal of Current Microbiology and Applied Sciences, 3(5), 261-266, 2014.

[30]   | Gomashe A.V., Gulhane P.A. and Bezalwar P.M., “Isolation and Screening of Cellulose Degrading Microbes from Nagpur Region Soil,” International Journal of Life Sciences, 1(4), 291-293, 2013.
[31]   | Talia P., Sede S.M., Campos E., Rorig M., Principi D., Tosto D., Hopp H.E., Grasso D. and Cataldi A., “Biodiversity characterization of cellulolytic bacteria present on native Chaco soil by comparison of ribosomal RNA genes,” Res. Microbiol., 163(3), 221-232, 2012.
[32]   | Ekperigin M.M., “Preliminary studies of cellulase production by Acinetobacter anitratus and Branhamella sp,” African Journal of Biotechnology, 6(1), 28-33, 2007.
[33]   | Chantawannakul P, Oncharoen A, Klanbut K, Chukeatirote E, Lumyong S., “Characterization of proteases of Bacillus subtilis strain 38 isolated from traditionally fermented soybean in Northern Thailand,” Science Asia, 28 (4), 241-5, Sep 2002.
[34]   | Abdel-Mawgoud, A.M., Aboulwafa, M.M. and Hassouna, N.A.H., “Optimization of surfactin production by Bacillus subtilis isolate BS5,” Applied Biochemistry and Biotechnology, 150(3), 305-325, 2008.
[35]   | Bakare MK, Adewale IO, Ajayi A, Shonukan OO., “Purification and characterization of cellulase from the wild-type and two improved mutants of Pseudomonas fluorescens,” African Journal of Biotechnology, 4(9), 2005.
[36]   | Ray, A.K., Bairagi, A., Ghosh, K.S. and Sen, S.K., “Optimization of fermentation conditions for cellulase production by Bacillus subtilis CY5 and Bacillus circulans TP3 isolated from fish gut,” Acta Ichthyologica et Piscatoria, 1(37), 47-53, 2007.
[37]   | Ramana, K.V., Tomar, A. and Singh, L., “Effect of various carbon and nitrogen sources on cellulose synthesis by Acetobacter xylinum,” World Journal of Microbiology and Biotechnology, 16(3), 245-248, 2000.
[38]   | Saraswati, B., Ravi, K.M., Mukesh Kumar, D.J., Balashanmugam, P., Bala Kumaran, M.D. and Kalaichelvan, P.T., “Cellulase Production by Bacillus subtilis isolated from Cow Dung,” Archives of Applied Science Research, 4 (1). 269–279, 2012.
[39]   | Teodoro, C.E.D.S. and Martins, M.L.L., “Culture conditions for the production of thermostable amylase by Bacillus sp,” Brazilian Journal of Microbiology, 31(4), 298-302, 2000.
[40]   | Ikram-Ul-Haq, U.H., Shahzadi, K., Javed, M.S.A. and Qadeer, M.A., “Cotton saccharifying activity of cellulases by Trichoderma harzianum UM-11 in shake flask,” J Bot, 1(1), 19-22, 2005.
[41]   | Ariffin, H., Abdullah, N., Umi Kalsom, M.S., Shirai, Y. and Hassan, M.A., “Production and characterization of cellulase by Bacillus pumilus EB3,” International Journal of Engineering and Technology, 3(1), 47-53, 2006.